Moderators: richierich, ua900, hOMSaR

 
User avatar
bikerthai
Posts: 3249
Joined: Wed Apr 28, 2010 1:45 pm

Re: New advertisement: B-52 re-engine back in the mix?

Fri May 22, 2020 8:32 pm

Are they not going from a turbojet to a higher bypass ratio turbo fan?

That would require new nacelles as the by-pass duct geometry is quite different.

New pylons should also be in the works.

Wonder if they would include thrust reversers?

bt
Intelligent seeks knowledge. Enlightened seeks wisdom.
 
mmo
Posts: 1963
Joined: Thu Apr 18, 2013 3:04 pm

Re: New advertisement: B-52 re-engine back in the mix?

Fri May 22, 2020 9:05 pm

bikerthai wrote:
Wonder if they would include thrust reversers?

bt


After 2500 hours or so in the Buff, I can certainly guarantee you it won't happen. It's too much additional weight, too complex and most important of all, too much problems with directional control with asymmetrical reverse on a contaminated runway. A drag chute and anti-skid work just fine.
If you look at the KC-135R mod, they didn't add reverse on that mod. Will never happen.
If we weren't all crazy we'd all go insane!
 
User avatar
LyleLanley
Posts: 133
Joined: Wed Dec 18, 2019 9:33 pm

Re: New advertisement: B-52 re-engine back in the mix?

Fri May 22, 2020 9:18 pm

Not to be pedantic, but the KC-135 received thrust reversers when they were reengined from A to E.

The B-52 is, of course, a far different beast. TRs just aren’t worth the hassle to put on now.
"I've sold monorails to Brockway, Ogdenville, and North Haverbrook, and, by gum, it put them on the map!"
 
User avatar
kc135topboom
Posts: 11169
Joined: Sun Jan 30, 2005 2:26 am

Re: New advertisement: B-52 re-engine back in the mix?

Fri May 22, 2020 11:31 pm

Thrust reversers were offered with the KC-135R reengine program, the CFM-56 (F-108) engines were equipped with the mountings. SAC maintenance did not want them, fearing it would add to maintenance hours per tanker. So they were designed out of the modification. The modification did include new landing gear and 5 rotor brakes.
SAC KC-135 aircrews actually wanted TRs on thier airplanes, the extra weight was not a problem, and it would have opened KC-135R/T operations to many more airports than KC-135R/Ts without TRs.
The ANG was a little stuck with TRs for the KC-135E, but they wanted them anyway. The JT-3D (TF-33) engines were from donor B-707s that included the engine struts and horizontal stabilizers, throttle quadrant, engine instruments, and all associated mounting brackets and equipment. Everything came as a complete package. The "E" model included rebuilt landing gear and 5 rotor brakes.
Most KC-135 ANG pilots were also commercial airline pilots and a lot of the maintenance crews were also commercial airline maintenance people, TRs were less of a 'problem' for the maintenance people.
The "E" modification also found its way into some other air command's C-135 airplanes as well as a few SAC KC-135s based at OFF.
 
User avatar
kc135topboom
Posts: 11169
Joined: Sun Jan 30, 2005 2:26 am

Re: New advertisement: B-52 re-engine back in the mix?

Sat May 23, 2020 12:53 am

One of the engines considered for the B-52 reengining program is the GE CF-34-10E, with 20,360 lbs. of thrust (a modest increase over the current TF-33-P-3/-103, which has 17,000 lbs. of thrust), but has a dry weight nearly 1,000 lbs. lighter than the older engine (TF-33-P-3/-103 = 4,650 lbs. vs. CF-34-10E = 3,700 lbs.).
 
mmo
Posts: 1963
Joined: Thu Apr 18, 2013 3:04 pm

Re: New advertisement: B-52 re-engine back in the mix?

Sat May 23, 2020 5:59 am

LyleLanley wrote:
Not to be pedantic, but the KC-135 received thrust reversers when they were reengined from A to E.

The B-52 is, of course, a far different beast. TRs just aren’t worth the hassle to put on now.


Nothing wrong with being pedantic, but go back and read my thread. I specifically talked about the R model.



kc135topboom wrote:
Thrust reversers were offered with the KC-135R reengine program, the CFM-56 (F-108) engines were equipped with the mountings.

And at the end of the day, they weren' equipped with them.
If we weren't all crazy we'd all go insane!
 
User avatar
747classic
Posts: 2988
Joined: Sat Aug 15, 2009 9:13 am

Re: New advertisement: B-52 re-engine back in the mix?

Sat May 23, 2020 6:50 am

Thrust reversers on eight engines will add a lot of weight and maintenance and will not happen.
But I repeat it one more time :
Adding new engine pairs with different weights and/or different external aerodynamical pylon/engine shapes will require wing modifications due the changes in load distribution over the relative thin flexible wing.

IMHO the USAF has two options :

- Low risk option : adding of new aerodynamical identical engine cowlings /pylons for the new engines, with approx the same weight at each pylon. This configuration will not require a wing modification, but only the lower TSFC of the engines will be the gain + reduced maintenance costs.

- All new (high risk) option : adding optimal (different) shaped engine cowlings / pylons for the new engines and use the lower engine weights for increased payload. This modification will require extensive wing modifications and could introduce a lot of unknown issues (wing flutter). Also the certified external weapon loads will have to be re-certified. The extra gain will be : a little more fuel saving and/or increased payload.
Operating a twin over the ocean, you're always one engine failure from a total emergency.
 
rlwynn
Posts: 1462
Joined: Fri Dec 15, 2000 3:35 am

Re: New advertisement: B-52 re-engine back in the mix?

Sat May 23, 2020 7:02 am

bikerthai wrote:
Are they not going from a turbojet to a higher bypass ratio turbo fan?



No, That already happened when they got the TF-33.
I can drive faster than you
 
User avatar
LyleLanley
Posts: 133
Joined: Wed Dec 18, 2019 9:33 pm

Re: New advertisement: B-52 re-engine back in the mix?

Sat May 23, 2020 10:08 pm

mmo wrote:
LyleLanley wrote:
Not to be pedantic, but the KC-135 received thrust reversers when they were reengined from A to E...


Nothing wrong with being pedantic, but go back and read my thread. I specifically talked about the R model.


I know. But when you bring forth examples of reengined aircraft and specifically reference the AF's refusal to add TRs I thought it was proper to mention when the AF did add TRs. Especially if its the same aircraft you mention - the KC-135.
"I've sold monorails to Brockway, Ogdenville, and North Haverbrook, and, by gum, it put them on the map!"
 
giblets
Posts: 145
Joined: Fri Jun 21, 2013 8:34 am

New advertisement: B-52 re-engine back in the mix?

Sun May 24, 2020 8:16 am

There was a video online where sales guys from the 3 different manufacturers gave some spiel about each of their offering. If it was solely based on those guys, RR would win it (the P&W just kept saying it was a great time to upgrade lol). Offering a fairly technical talk through.
RR had a model with a couple of their engines in a B52 style pod, it was essentially a lot shorter than the current pods, not sure if that was just for the show or whether that’s the pod design the propose (the imagine behind them also shows a similar pod, looks more like the pod for the jp57!


https://www.defensenews.com/video/2019/ ... 4-options/


Sent from my iPhone using Tapatalk
146, ATR72, Q400, Saab 340, PA-46 Jetprop, Jetstream, E175/195, 707/727/737/747/757/767/777, DC-3/9/10, MD-11/80, A300/310/319/320/321/330/340/350/380 Tristar, BAC 1-11, Trident, Chipmunk, Bell 206/222, Chinook, Puma, Cessna 172, Fokker 70, 100, SRN4!

Who is online

Users browsing this forum: No registered users and 48 guests

Popular Searches On Airliners.net

Top Photos of Last:   24 Hours  •  48 Hours  •  7 Days  •  30 Days  •  180 Days  •  365 Days  •  All Time

Military Aircraft Every type from fighters to helicopters from air forces around the globe

Classic Airliners Props and jets from the good old days

Flight Decks Views from inside the cockpit

Aircraft Cabins Passenger cabin shots showing seat arrangements as well as cargo aircraft interior

Cargo Aircraft Pictures of great freighter aircraft

Government Aircraft Aircraft flying government officials

Helicopters Our large helicopter section. Both military and civil versions

Blimps / Airships Everything from the Goodyear blimp to the Zeppelin

Night Photos Beautiful shots taken while the sun is below the horizon

Accidents Accident, incident and crash related photos

Air to Air Photos taken by airborne photographers of airborne aircraft

Special Paint Schemes Aircraft painted in beautiful and original liveries

Airport Overviews Airport overviews from the air or ground

Tails and Winglets Tail and Winglet closeups with beautiful airline logos